Author Topic: spray'n'wipe (Read 10329 times)

Adam · « **on:** February 16, 2003, 11:56:02 PM »

Took, the corvette out for its daily flight and I noticed a slight and non consistant power loss, hmm, methinks, loose plug, maybe sh*@ engine?

no.

Upon inspection I found a little rubber cap that sits on the manifold had a crack which was now a coolant leak. The higher the revs, the further it sprayed. Whats more it sprayed forward onto the fan which evenly distributed coolant all over the engine bay...YES!

Cost of rubber cap = 99c
Cost of cleaning = a few hours

Just somthing to think about next time u pop the hood....

Adam

77CVT · « **Reply #1 on:** February 17, 2003, 10:17:05 AM »

Ouch! At least it wasn't anything terminal.

Brutus · « **Reply #2 on:** February 17, 2003, 03:04:00 PM »

With cars as old as ours, it pays to check them out just that little bit more often.
It's a never ending thing, but that's just the way I like it.;laugh

Vette Obsessed · « **Reply #3 on:** February 17, 2003, 08:03:56 PM »

Quote

Originally posted by Brutus
With cars as old as ours, it pays to check them out just that little bit more often.

I don't think age has anything to do with it when it comes to most Corvettes. Then again, maybe I like to look for excuses to pull things apart...:mmm

rebel · « **Reply #4 on:** February 17, 2003, 08:23:57 PM »

Quote

Cost of rubber cap = 99c
Cost of cleaning = a few hours

Lesson Learned .... priceless ...

- sorry, couldn't help myself ;laugh

Seriously though, I had a similar thing happen with the cap on my water reserve bottle. There was no power loss or anything except that the fans kept running, but green coolant all over the place !

johnny86convert · « **Reply #5 on:** February 17, 2003, 08:28:35 PM »

hey whitey you should see what a leaky water pump can spray in the engine bay of a big block 2km away from a convention in brisbane, we thought I'd collected kermit with all the green muck about lololololololo, glad you didn't have more damage ;)

Adam · « **Reply #6 on:** February 17, 2003, 09:14:29 PM »

Lucky my filter wasnt paper

69 DIRTY RAT · « **Reply #7 on:** February 17, 2003, 10:47:01 PM »

OUT COME THE OVER HEATING STORIES!.WHILST LIVING IN THE U.S I WAS DRIVING MY VETTE BACK FROM A TRIP TO SAN FRAN ON THE 5 FREEWAY IN THE 45C DESERT HEAT (WITH NO AIRCON),WHEN THERE WAS A TRAFFIC HOLD UP CAUSED FROM AN ACCIDENT.SO I WAS STATIONARY FOR ABOUT AN HOUR,THEN IT EVENTUALLY STARTED MOVING-SLOWLY.THEN AS I APPROACH AN UPHILL MOUNTAIN SECTION MY POOR BIG BLOCK SAID "ENOUGH IS ENOULD".THE TEMP GAUGE HIT THE END,I COULDNT PULL OVER DUE TO 3 LANES OF TRAFFIC FLYING PAST ME(I'M THINKIN ENGINE SEIZURE FOR SURE).i SAW A SIGN FOR A PULL OVER STOP ABOUT 2 MILES AWAY-PANIC PANIC.I MADE IT ,PULLED OVER OPEN THE HOOD AND IT WAS SPEWING OUT FROM UNGER THE CAP!LET IT COOL FOR A BIT THEN OPEN THE CAP-NO IT WAS STILL TO HOT HENCE THE GREEN STUFF SHOT 6FT INT THE AIR.EVENTUALLY AN HOUR LATER I PUT WATER IN AND DROVE OFF.I MADE IT HOME! NEVER AGAIN DRIVE THROUGH A DESERT!!!!!;30;30;30;30

rebel · « **Reply #8 on:** February 17, 2003, 10:50:39 PM »

you've been watching the wrong ad's mate ...

Desert = Pajero!
Freeway = Corvette .... :22

Adam · « **Reply #9 on:** February 17, 2003, 10:55:13 PM »

Yes, lets talk about heat, my vette has never overheated, even when the water wasnt full.

But whats got me stumped is why does it run hotter on the freeway than in traffic?
Yes, even after a freeway run, getting back into traffik makes the needle back off.

I don't think its a grounding problem btw, its always done this, even after I took a direct cable from the battery and grounded the guages.

Adam